Oldham Clinical Waste Incinerator

Clinical Waste Incinerator operated by Stericycle (SRCL) Ltd and located at the Royal Oldham Hospital.

Oldham Clinical Waste Incinerator
Site Location See HT & Clin → page for a larger UK Wide map.
Waste Licence	ZP3230XC
Operator	SRCL
Operational Capacity	7,446tpa
Number of Lines	1
Region	North West

Annual Report Data

Year	Total In	Total Clinical	IBA Out	ACP Out	Op Hours
2019	6464	6399	1215	514	7772
2018
2017
2020	7353	6492	1188	476	8013
2021	6140	6066	1130	366	7606
2022	6246	6173	1066	377	7398

Oldam Clinicla Waste Incinerator - captured from Google Street View - all rights reserved

Summary

Clinical Waste Incinerator operated by Stericycle (SRCL) Ltd and located at the Royal Oldham Hospital. The plant consists of a single stream, rated at 850 kilograms per hour or 7,446 tonnes per annum of solid wastes. The Primary Chamber operates the rotary kiln design to provide good mixing of the waste coupled to sufficient retention time to burn the wastes to a high quality ash.

Plant

Waste is loaded mechanically into the Primary Chamber using a hydraulic lift and tip arrangement, to avoid any manual handling of the waste. The rotating action of the rotary kiln provides good mixing of the waste, exposing fresh surfaces to combustion conditions. The combustion process is operated slightly in the sub-stoichiometric or starved air mode to produce volatile gases to fuel the Secondary Chamber while providing good burnout of the fixed carbon in the waste to produce bottom ash. The bottom ash is discharged from the end of the rotary kiln into an ash quench system to cool it rapidly, and from the ash quench pit it is discharged into storage skips. The skips of bottom ash are taken to a licensed landfill site for disposal as Non-Hazardous Waste.

The combustion gases produced in the Primary Chamber then pass into the Secondary Chamber, which operates at a minimum temperature of 850°C during start-up using Non-Hazardous Waste; and at a minimum temperature of 1000°C when Hazardous Waste may be loaded. The Secondary Chamber provides a minimum of two seconds residence time under oxygen-rich conditions to combust any Carbon Monoxide and volatile organic compounds produced in the Primary Chamber.

The hot gases then pass through a boiler and dilution air system, which reduce the temperature from above 1000°C to around 160°C, before the gases pass on to the flue gas treatment system.

Waste Tonnage, By Origin

The table shows a list of the Waste for the Permit ZP3230XC, that has arrived into sites as reported to the Regulator and then publicised in their reported statistics. The Data was last updated on Oct-24. The total reported tonnage arriving at the site was: 6,785.22t.

Where this tonnage exceeds that reported in year of the corresponding annual report, this may be due to the following reasons:

• Tonnage may have been received but not incinerated, i.e. the material is held pending incineration (the operator return to the EA reports as received whereas the annual report focuses on when the waste is incinerated.)
• Material may have been received into the site but treated in some other way than incineration.
• Material may have been received on the but transferred out of site for disposal/treatment at another site rather than incineration on the site.

EWC Code	Origin of Waste	Tonnes In
15 01 10*	Stockton-on-Tees	0.25
18 01 01	Cannock Chase	0.01
18 01 01	Fareham	6.45
18 01 01	High Peak	1.35
18 01 01	North West	0.21
18 01 01	Rhondda Cynon Taf	0.15
18 01 01	South Staffordshire	0.04
18 01 01	West Midlands	0.05
18 01 02	North West	0.17
18 01 03*	Aberdeen City	0.37
18 01 03*	Aberdeenshire	0.11
18 01 03*	Antrim and Newtownabbey	1.86
18 01 03*	Ashfield	1.25
18 01 03*	Bolsover	0.74
18 01 03*	Boston	0.92
18 01 03*	Bradford	0.14
18 01 03*	Bridgend	0.86
18 01 03*	Bristol, City of	2.53
18 01 03*	Burnley	131.75
18 01 03*	Caerphilly	0.11
18 01 03*	Calderdale	0.53
18 01 03*	Cannock Chase	0.09
18 01 03*	Cardiff	3.7
18 01 03*	Carmarthenshire	1.46
18 01 03*	Ceredigion	0.98
18 01 03*	Charnwood	0.04
18 01 03*	Cheltenham	5.01
18 01 03*	Cherwell	0.65
18 01 03*	Cheshire East	22.22
18 01 03*	Cheshire West and Chester	0.35
18 01 03*	City of Edinburgh	0.86
18 01 03*	Conwy	2.86
18 01 03*	County Durham	0.17
18 01 03*	Cumberland	0.12
18 01 03*	Denbighshire	35.48
18 01 03*	Derby	18.27
18 01 03*	Derbyshire Dales	0.1
18 01 03*	Ealing	0.09
18 01 03*	East Lindsey	0.09
18 01 03*	East Midlands	52.94
18 01 03*	East Riding of Yorkshire	0.06
18 01 03*	East Staffordshire	2.34
18 01 03*	Erewash	0.02
18 01 03*	Fareham	48.4
18 01 03*	Gateshead	0.06
18 01 03*	Gwynedd	22.81
18 01 03*	High Peak	4.53
18 01 03*	Isle of Anglesey	0.36
18 01 03*	Leeds	5.94
18 01 03*	London	0.25
18 01 03*	Mansfield	0.67
18 01 03*	Melton	0.03
18 01 03*	Merthyr Tydfil	0.95
18 01 03*	Midlothian	2.81
18 01 03*	Neath Port Talbot	0.05
18 01 03*	Newark and Sherwood	0.32
18 01 03*	Newcastle upon Tyne	1.12
18 01 03*	Newport	0.54
18 01 03*	North Ayrshire	0.48
18 01 03*	North East	1.58
18 01 03*	North East Lincolnshire	1.07
18 01 03*	North Northamptonshire	2.16
18 01 03*	North Tyneside	0.13
18 01 03*	North West	4364.02
18 01 03*	North West Leicestershire	0.89
18 01 03*	North Yorkshire	0.58
18 01 03*	Northumberland	4.23
18 01 03*	Nuneaton and Bedworth	2.87
18 01 03*	Oadby and Wigston	0.28
18 01 03*	Pembrokeshire	0.3
18 01 03*	Pendle	0.31
18 01 03*	Perth and Kinross	0.31
18 01 03*	Redcar and Cleveland	0.07
18 01 03*	Rhondda Cynon Taf	3.24
18 01 03*	Rochdale	35.17
18 01 03*	Rossendale	2.04
18 01 03*	Rushcliffe	2.36
18 01 03*	Scotland	7.2
18 01 03*	Shropshire	1.17
18 01 03*	South Holland	0.06
18 01 03*	South Kesteven	0.29
18 01 03*	South Staffordshire	0.04
18 01 03*	St Helens	5.25
18 01 03*	Stafford	0.33
18 01 03*	Stockton-on-Tees	0.18
18 01 03*	Sunderland	1.63
18 01 03*	Tameside	2.36
18 01 03*	Torfaen	1.33
18 01 03*	Trafford	6.39
18 01 03*	Vale of Glamorgan	1.45
18 01 03*	Wales	2.89
18 01 03*	Walsall	0.01
18 01 03*	Warwick	4.9
18 01 03*	West Lindsey	0.03
18 01 03*	West Lothian	6.63
18 01 03*	West Midlands	124.73
18 01 03*	West Northamptonshire	0.01
18 01 03*	Westmorland and Furness	0.02
18 01 03*	Wirral	23.58
18 01 03*	Wolverhampton	0.04
18 01 03*	Worthing	0.01
18 01 03*	Wrexham	43.49
18 01 03*	York	0.3
18 01 03*	Yorks & Humber	22.73
18 01 04	Ashfield	0.2
18 01 04	Boston	0.53
18 01 04	Burnley	0.9
18 01 04	Calderdale	0.56
18 01 04	Cheshire East	3.01
18 01 04	Derby	0.13
18 01 04	East Midlands	1.85
18 01 04	East Staffordshire	0.19
18 01 04	Gwynedd	0.13
18 01 04	High Peak	14.49
18 01 04	Midlothian	0.35
18 01 04	Newark and Sherwood	0.03
18 01 04	North West	1050.02
18 01 04	Redcar and Cleveland	0.32
18 01 04	Rochdale	1.43
18 01 04	Rossendale	0.01
18 01 04	Rushcliffe	0.48
18 01 04	Scotland	1.46
18 01 04	Shropshire	0.32
18 01 04	Stockton-on-Tees	0.25
18 01 04	Tameside	0.11
18 01 04	Trafford	0.28
18 01 04	West Midlands	1.12
18 01 04	West Northamptonshire	0.04
18 01 04	Wirral	0.02
18 01 04	Wrexham	0.6
18 01 04	Yorks & Humber	0.94
18 01 06*	Cheshire East	0.1
18 01 06*	Derby	0.7
18 01 06*	East Midlands	0.05
18 01 06*	Fareham	0.57
18 01 06*	Gwynedd	3.12
18 01 06*	North West	0.44
18 01 06*	Pendle	1.05
18 01 06*	Warwick	0.12
18 01 06*	West Midlands	0.17
18 01 06*	Wirral	0.03
18 01 08*	Antrim and Newtownabbey	32.53
18 01 08*	Boston	0.05
18 01 08*	Bristol, City of	0.04
18 01 08*	Burnley	4.33
18 01 08*	Calderdale	0
18 01 08*	Cardiff	0.43
18 01 08*	Carmarthenshire	0.03
18 01 08*	Ceredigion	0.11
18 01 08*	Charnwood	0.06
18 01 08*	Cheltenham	1.02
18 01 08*	Cheshire East	3.26
18 01 08*	City of Edinburgh	0.04
18 01 08*	Conwy	0.12
18 01 08*	Denbighshire	5.09
18 01 08*	Derby	1.35
18 01 08*	East Midlands	3.12
18 01 08*	East Staffordshire	0.72
18 01 08*	Gwynedd	4.27
18 01 08*	High Peak	0
18 01 08*	Isle of Anglesey	0.03
18 01 08*	Leeds	0.07
18 01 08*	Merthyr Tydfil	0.04
18 01 08*	Newark and Sherwood	0.04
18 01 08*	Newcastle upon Tyne	0.29
18 01 08*	Newport	0.09
18 01 08*	North East	0.11
18 01 08*	North Northamptonshire	0.26
18 01 08*	North West	254.36
18 01 08*	Nuneaton and Bedworth	0.31
18 01 08*	Oadby and Wigston	0.04
18 01 08*	Pembrokeshire	0.03
18 01 08*	Rhondda Cynon Taf	0.27
18 01 08*	Rochdale	0
18 01 08*	Rossendale	0
18 01 08*	Scotland	1.03
18 01 08*	South Kesteven	0.05
18 01 08*	St Helens	0.11
18 01 08*	Tameside	0.01
18 01 08*	Wales	0.31
18 01 08*	Warwick	0.44
18 01 08*	West Midlands	6.64
18 01 08*	Wirral	0.37
18 01 08*	Wrexham	0.85
18 01 08*	Yorks & Humber	0.78
18 01 09	Boston	0.2
18 01 09	Bradford	0.07
18 01 09	Bristol, City of	0.03
18 01 09	Burnley	9.28
18 01 09	Calderdale	0.96
18 01 09	Cardiff	0.24
18 01 09	Cheltenham	0.15
18 01 09	Cheshire East	0.51
18 01 09	City of Edinburgh	0.19
18 01 09	Denbighshire	0.84
18 01 09	Derby	1.93
18 01 09	East Midlands	3.2
18 01 09	East Staffordshire	0.14
18 01 09	Fareham	3.89
18 01 09	Gwynedd	0.45
18 01 09	High Peak	0.13
18 01 09	Leeds	0.23
18 01 09	Newcastle upon Tyne	0.41
18 01 09	Newport	0.07
18 01 09	North East	2.1
18 01 09	North West	132.91
18 01 09	North West Leicestershire	0.16
18 01 09	Nuneaton and Bedworth	1.07
18 01 09	Rhondda Cynon Taf	1.39
18 01 09	Rochdale	1.25
18 01 09	Rossendale	0.1
18 01 09	Scotland	1.75
18 01 09	Shropshire	0.26
18 01 09	St Helens	0.67
18 01 09	Stratford-on-Avon	0.03
18 01 09	Tameside	0.23
18 01 09	Torfaen	0.1
18 01 09	Wales	0.1
18 01 09	Warwick	0.28
18 01 09	West Lothian	0.76
18 01 09	West Midlands	14.1
18 01 09	Wirral	0.86
18 01 09	Wrexham	0.26
18 01 09	York	0.05
18 01 09	Yorks & Humber	0.79
18 02 02*	Cheshire West and Chester	6.99
18 02 02*	City of Edinburgh	0.75
18 02 02*	East Midlands	3.45
18 02 02*	Gwynedd	0.08
18 02 02*	High Peak	0.07
18 02 02*	Melton	0.35
18 02 02*	Midlothian	1.52
18 02 02*	North Ayrshire	1.31
18 02 02*	North East	1.01
18 02 02*	North Lincolnshire	0.18
18 02 02*	North West	16.76
18 02 02*	North West Leicestershire	0.89
18 02 02*	Rochdale	0.33
18 02 02*	Scotland	4.04
18 02 02*	South Derbyshire	0.23
18 02 02*	South Ribble	0.95
18 02 02*	West Midlands	5.12
18 02 02*	Wirral	0.25
18 02 02*	Wrexham	0.1
18 02 02*	Yorks & Humber	1.2
18 02 03	Cheshire East	4.84
18 02 03	North East	0.23
18 02 03	North Lincolnshire	0.27
18 02 03	North West	19.54
18 02 03	Rochdale	0.02
18 02 03	West Midlands	0.34
18 02 03	Westmorland and Furness	0.18
18 02 03	Yorks & Humber	0.02
18 02 05*	North Ayrshire	0.33
18 02 07*	North West	0.32
18 02 07*	South Ribble	0.03
18 02 07*	West Lothian	0.05
18 02 08	High Peak	0.01
18 02 08	North Ayrshire	0.14
18 02 08	North East	0.08
18 02 08	North Lincolnshire	0.14
18 02 08	North West	5.43
18 02 08	Scotland	0.32
18 02 08	South Ribble	0.82
18 02 08	West Lothian	0.1
20 01 99	Cannock Chase	0.05
20 01 99	Cheshire East	0.55
20 01 99	Conwy	0.28
20 01 99	High Peak	0.13
20 01 99	Midlothian	0.29
20 01 99	North West	47.86
20 01 99	Rochdale	0.16
20 01 99	Scotland	0.02